Traditional organic tail gas treatment mainly relies on activated carbon adsorption and RTO combustion. These two roads can meet the standards, but each has its own price. Activated carbon adsorption transfers organic matter from the gas phase to the solid phase, and saturated carbon becomes a hazardous waste, requiring ongoing disposal costs, management
2026-07-20The organic solvent in VOCs waste gas is the raw material of the wrong position. The combined process of compression condensation and membrane separation is to separate these solvents from the waste gas and turn them into reusable liquid resources. The process takes pure physical separation as the core,
2026-07-18Compression condensation membrane separation, high concentration waste gas treatment preferred process high concentration VOCs waste gas treatment, the key is to recover rather than destroy. Although the incineration method can meet the standard, the annual gas cost of hundreds of thousands plus the value of the burned solvent
2026-07-18In the field of VOCs waste gas treatment, incineration and adsorption are two traditional paths. Incineration burns organic matter into carbon dioxide and water, and the exhaust gas may carry combustion by-products such as nitrogen oxides; adsorption transfers organic matter from the gas phase to the solid phase, saturated
2026-07-18The compression and condensation membrane separation equipment adopts a skid-mounted structure, and the compressor, condenser, membrane module and control system are all integrated on the steel base, and the assembly and debugging are completed before leaving the factory. After the equipment arrives at the site, it can be transported only by connecting the power supply and gas circuit.
2026-07-18For medium and high concentration VOCs waste gas (usually above 1000 mg/m), activated carbon adsorption saturation is too fast, RTO combustion will burn the solvent in vain, and the gas fee will be paid. The combined process of compression condensation membrane separation takes the recovery route--
2026-07-15Incineration and adsorption are the two old ways of VOCs waste gas treatment. The principle of incineration (RTO/TO) is high temperature oxidation, burning organic matter into carbon dioxide and water; adsorption by activated carbon to trap organic matter in the pore. Two roads
2026-07-15In the treatment of VOCs waste gas, the combined process of compression condensation and membrane separation has become a mature technical route for the treatment of organic waste gas with medium and high concentration and recovery value because of its characteristics of both standard emission and solvent reuse.
2026-07-15The combined process of compression and condensation membrane separation is a relatively mature technical route in the resource recovery of VOCs. The process couples the two technical gradients of three-stage condensation and membrane separation to form "three-stage condensation is responsible for the recovery of the main body and membrane separation."
2026-07-15In VOCs waste gas treatment, a single condensation process is limited by the gas-liquid equilibrium, even if the temperature is reduced to very low, a certain concentration of organic matter will remain in the tail gas-the higher the recovery rate, the greater the increase in marginal energy consumption. Although a single membrane separation can be efficient
2026-07-14Mr. Li 13526990215
Hotline
