Toluene system condensation large head, membrane control low concentration segment, this paper explains the two-stage combination of temperature convergence, medium adaptation and operation management.
2026-10-07Ethylene oxide tail gas has special components and high safety requirements, and this paper explains the division of labor and combination process of compression condensation and membrane separation.
2026-10-06Pressure difference is the driving force of membrane separation, this paper explains the pressure difference and vacuum degree management of membrane device, the requirements of steady flow and voltage stabilization and the key points of inspection.
2026-10-06Feed concentration and air flow rate fluctuate with production; this paper describes the load assessment of the condensation recovery unit, the combination of control strategies, and energy-saving operational arrangements.
2026-10-06The exhaust from vacuum pumps carries large amounts of solvent vapor, representing a significant but often overlooked source of losses. This article describes the collection and condensation configurations for vacuum system tail gases, as well as their operational management.
2026-10-05Frosting is the normal state of cryogenic operation, properly managed does not constitute a burden, this paper explains the frost layer judgment, defrosting mode selection and cycle arrangement.
2026-10-04The refrigeration section determines the lower limit of the temperature level of condensation recovery, and this paper compares the characteristics and selection considerations of two-stage compression and cascade refrigeration.
2026-10-03The heat exchanger is the core component of condensation recovery, and this paper compares the applicable occasions and selection considerations of the two types of structures of plate type and tube shell type.
2026-10-02The buffer tank is the key component to stabilize the fluctuation of gas volume, and this paper explains the key points of its volume determination, location arrangement and operation management.
2026-10-01The layered tank is the first pass of condensate reuse, and this paper explains the static time arrangement, the operation method of interface control and the key points of reuse quality management.
2026-09-30Mr. Li 13526990215
Hotline
