In the field of VOCs waste gas treatment, incineration and adsorption are two traditional paths. Incineration burns organic matter into carbon dioxide and water, and the exhaust gas may carry combustion by-products such as nitrogen oxides; adsorption transfers organic matter from the gas phase to the solid phase, saturated
2026-07-18The compression and condensation membrane separation equipment adopts a skid-mounted structure, and the compressor, condenser, membrane module and control system are all integrated on the steel base, and the assembly and debugging are completed before leaving the factory. After the equipment arrives at the site, it can be transported only by connecting the power supply and gas circuit.
2026-07-18In VOCs waste gas treatment, a single condensation process is limited by the gas-liquid equilibrium, even if the temperature is reduced to very low, a certain concentration of organic matter will remain in the tail gas-the higher the recovery rate, the greater the increase in marginal energy consumption. Although a single membrane separation can be efficient
2026-07-14VOCs waste gas treatment process selection, concentration is a key basis for judgment. When the concentration is low, the condensation recovery efficiency is not ideal, and the economy is not obvious; when the concentration is too high, the activated carbon adsorption saturation is too fast, and the RTO combustion faces the calorific value
2026-07-14Compression condensation membrane separation process: physical separation, no secondary pollution compression condensation membrane separation process is a pure physical separation as the core of the VOCs waste gas treatment method. Unlike activated carbon adsorption or high temperature incineration, the process is full.
2026-07-14VOCs exhaust gas treatment, a single process is often lost. The condensation method can recover the solvent, but it is limited by the gas-liquid equilibrium, there is always a residue in the tail gas, and the emission concentration is difficult to meet the environmental protection standards. Membrane separation can be highly concentrated, but not directly liquefied
2026-07-14Compressed condensation membrane separation, combined process of VOCs treatment A single VOCs treatment technology often has shortcomings: condensation treatment of high concentration exhaust gas energy consumption is high, treatment of low concentration exhaust gas efficiency is low and difficult to meet the standard;
2026-07-14Compression condensation plus membrane separation, waste gas solvent recovery scheme process principle compression condensation plus membrane separation combination process, is the current VOCs resource recovery in the more mature technical route. The process will compress, condense and film
2026-07-14Traditional VOCs exhaust gas treatment often requires a special person to inspect regularly, manually adjust parameters, and record operating data. The labor cost and management burden are not low. Wo Hong's skid-mounted condensing membrane separation unit, through the PLC automatic control system,
2026-07-13The installation of traditional VOCs processing equipment often takes a long time, with on-site construction, pipeline welding and instrument debugging ranging from weeks to months, and the delay in construction period affects normal production. Wohong skid-mounted VOCs processing equipment has changed this situation.
2026-07-13Mr. Li 13526990215
Hotline
